Biogas desulfurization is not only a simple and relatively low-cost desulfurization method, but also a more widely used desulfurization method. The basic principle of the equipment for removing hydrogen sulfide from biogas by dry method is the method that O2 oxidizes hydrogen sulfide (H2S) into sulfur or thiooxide, which can also be called dry oxidation method. The filler is placed inside, and the filler layer includes activated carbon, iron oxide, etc. Nowadays, iron oxide is more commonly used. The gas enters the container from the inlet at one end at a low flow rate and passes through the packing layer in the container. Hydrogen sulfide (H2S) is oxidized into sulfur or sulfur oxide compounds and retained in the packing layer. The purified gas is discharged from the air outlet at the other end of the container.

yl6809永利的运行和维护应符合下列要求：

The operation and maintenance of biogas desulfurization shall meet the following requirements:

1、脱水脱硫装置中的冷凝水应定期排放。当室外温度接近0°C时，应每天排放冷凝水，并在排放时防止沼气泄漏。

1. The condensate in the dehydration and desulfurization unit shall be discharged regularly. When the outdoor temperature is close to 0 ° C, the condensate shall be discharged every day and the biogas leakage shall be prevented during discharge.

2、生物脱硫开始并正常进行后，应定期检查脱硫前后的硫化氢浓度变化，并且硫化氢的去除率应符合后端工艺的要求。当发现脱硫效率大大降低时，应及时补充循环的营养液。塔中的填料应每6-12个月清洁一次。

2. After biological desulfurization is started and carried out normally, the change of hydrogen sulfide concentration before and after desulfurization shall be checked regularly, and the removal rate of hydrogen sulfide shall meet the requirements of back-end process. When the desulfurization efficiency is greatly reduced, the circulating nutrient solution shall be supplemented in time. The packing in the tower shall be cleaned every 6-12 months.

3、应当定期检查干燥脱硫塔前后的硫化氢浓度和沼气压力变化。当不满足设计要求时，应更换脱硫剂或进行脱硫再生。

3. The changes of hydrogen sulfide concentration and biogas pressure before and after drying the desulfurization tower shall be checked regularly. When the design requirements are not met, the desulfurizer shall be replaced or desulfurization regeneration shall be carried out.

4、干式脱硫塔的再生应满足以下要求：

4. The regeneration of dry desulfurization tower shall meet the following requirements:

1）在塔内使用脱硫剂进行再生时，应关闭沼气的进，出口阀门，并旁路支管和排放阀门管道应打开。

1) When desulfurizer is used for regeneration in the tower, the inlet and outlet valves of biogas shall be closed, and the bypass branch pipe and discharge valve pipeline shall be opened.

2）当使用在线脱硫器再生时，应根据沼气中的硫化氢含量确定空气混合量和空气流速，塔内温度应低于70℃，且塔内的氧含量脱硫塔出口沼气应小于1％;

2) When the on-line desulfurizer is used for regeneration, the air mixing amount and air flow rate shall be determined according to the hydrogen sulfide content in the biogas. The temperature in the tower shall be lower than 70 ℃, and the oxygen content in the tower shall be less than 1% of the biogas at the outlet of the desulfurization tower;

3）脱硫剂应在2〜3次再生后及时更换。更换脱硫剂时，操作员应戴防毒面具，房间应通风。

3) The desulfurizer shall be replaced in time after 2 ~ 3 times of regeneration. When replacing desulfurizer, the operator shall wear gas mask and the room shall be ventilated.

4）yl6809永利废脱硫器的处置应符合环境保护要求。

4) The disposal of biogas desulfurization waste desulfurizer shall meet the requirements of environmental protection.